For growth and prosperity

For growth and prosperity

Saturday 13 December 2014

Banana Bunch Care and methods to maximize Bunch size


Banana Bunch Care and some proven procedures 
to maximize the Bunch size:
To attain maximum yield in Banana cultivation, follow the latest cultivation practices give here:
A model of 'DBT' certificate
  • Prefer Tissue culture banana plants from 'DBT' (Department of Biotechnology) certified biotech companies.
  • Avoid cultivating banana in problematic soils like ‘Acidic’, ‘Alkaline’ and ‘Saline’ soils.
  • Ensure irrigation water quality and avoid water with EC of >1.
  • Give priority to good water management (To avoid water Stress, go for Drip irrigation system).
  • Follow good Integrated Pest Management (IPM) practices.
  • Follow good Integrated Disease Management (IDM) practices.
  • Strictly follow all the 'Bunch care techniques' explained here to maximize bunch size. Always bear in mind that the price of Banana is NOT directly in proportionate to the quality of produce. In the trading of banana, fruit quality is valued more in fixing the price. So, strive to achieve the best in quality.
    Details of Banana Bunch care & methods to enhance the bunch size:

1. Bell injection -  Injection on inflorescence bud to control sucking insect pests infesting on developing fingers:

Bell Injection is given when the emerging inflorescence (Flower) bud is in upright position. It gives complete protection from pests that damage the developing bunch as the bell emerges.
 
The injection should be given at 1 / 4th place from top of the bud.

To prevent clogging of the needle, first make a hole at the desired point with a small needle and then use the syringe.   




Prepare a solution of Imidacloprid 17.8 EC (Brand: Confidor)    @ 0.2 ml in 1 litre of water and take 2 ml solution in a disposable Insulin syringe. Inject the entire 2 ml in the bud in a 30 degree angle.


(OR)
 
Prepare a solution of 0.1% (One ml in 1 litre of water) of Imidacloprid 17.8 EC (Brand: Confidor) and pump a full single dose of 40 ml of the solution into the flower bud thereby fully drenching the bud using "Banana Bell Injector pump". 





Pictures courtesy: http://treeinjectors.com/ and  
http://www.saspl.com.au/product/banana-bell-injection-poster-2/

2.  Banana Deflowering:
                Banana Deflowering














3.  Placing perforated sheet as cushion between separated hands:
Placing perforated sheets between hands












.
 .

4.  De-navelling (Removal of male floral bud):

It helps in fruit development and increase of bunch weight. 

The male flower bud should be removed one month after emergence of the last hand. 

By this removal of unwanted male flower bud, which is prone to infections, incidence of pest and disease attack on bunch can be minimized. 

In some parts of Tamilnadu, farmers leave them as such up to the time of harvest, resulting in elongation of stem with the male flower bud up to the ground.


5.  Covering the peduncle (Peduncle wrapping) to protect it from sunburn or scorching:
Flag leaf / Boot leaf - Nature's umbrella Gift.
A 'Boot leaf / Flag leaf ' emerges from the plant just before the bunch emergence and its main purpose is to protect the top curved part of the peduncle and upper portion of the bunch from sunburn or scorching. 

If this natural protection gets damaged due to wind or pest attack, the upper exposed part of peduncle will get sun burned (Sun scorched). 

This subsequently leads to rotting of peduncle due to secondary infection of 'Colletotrichum fungus'.  Incidence of sun scorching will be severe if bunch emergence coincides with hot summer months. Since nutrient and water flow from the main stem to bunch gets arrested, immature ripening will occur resulting in very poor bunch development and ultimately breaking of the peduncle along with the bunch.
Remedial measures: 
  • To prevent sunburn and the resultant fungal infections, the peduncle exposed to scorching sun should be wrapped with the flag leaf and other banana leaf trashes.
  • If the sun scorching happens before initiating any protective measure, apply a thick solution of 2% COC (Fytolan or Blue Copper) on the affected area using a wall painting brush and cover the affected portion using banana trash leaves.     
6.  Effects of covering Banana bunch (Skirting) with polythene Bunch covers / sleeves or Non-woven skirting bags :
Usage of Banana bunch cover
  1. Bunches are covered with 6% ventilated Polythene covers / sleeves of size 200cm Length x 150cm width x 175 gauge thick. 
  2. Use opaque polythene covers / sleeves if bunch development is during winter and paper bags can also be used to avoid chilling injury at frost conditions. 
  3. Use blue color bunch cover / sleeves during summer to avoid sun scorch.
  4. Do it within 15 days of last hand opening.
  5. The bunch is free from insect bites, fungi, bacteria attacks and physical injuries.
  6. Improved bunch appeal. 
  7. Maturity of bunch will be advanced by 7 to 10 days.


             Placing inserts and skirting the bunch 
with covers / sleeve














Using blue color bunch covers / sleeves 
during summer to avoid sun scorch.
Using Bunch cover made of paper 
to prevent chilling injury at frost conditions

7.   At the banana bunch development stage the following fertilizers are  normally recommended to enhance the size of fruits / bunch: 

Option 1: Application of 2% (20gm / 1litre) Potassium sulphate (0:0:50) as foliar spray on bunches, two times with 15 days interval.
(OR)
Option 2: Application of 1% (10gm / 1litre) Potassium nitrate (13:0:45) as foliar spray on bunches, two times with 15 days interval.
(OR)
Option 3 (Considered as best since it addresses all nutritional deficiencies): Application of 0.5% (5gm / 1litre) Potassium nitrate (13:0:45) + 0.5% (5gm / 1litre) of foliar grade Micro nutrient mixture as foliar spray on bunches as first spray followed by a second application of 2% (20gm / 1litre) of Potassium sulphate (0:0:50) + Biozyme 2ml / 1litre after 15 days. Repeat the second one again as III application after 15 days interval.

Important Note 1: In all the above applications you can also add 0.2% Bavistin (Fungicide) for prophylactic control of fungal infections. Use wetting agents also. 


Important Note 2: Nowadays farmers are going for a minimum of four applications within a period of 60 days (4 sprays with 15 days interval between each spray) and are getting very good results. 

Precautions: 
  • Care should be taken to spray the above fertilizers only after all the hands are fully opened and after sufficient extension of male flower bud in the rachis. 
  • Do not apply any fertilizers or pesticides 15 days before harvest since there is a possibility of the unabsorbed chemical residues entering human food chain.
  • Application of excess dosage of fertilizers, Enzymatic and synthetic Growth promoters and plant protection chemicals on bunches are to be strictly avoided. See the link:Effect of overdose.
Option 4:    Enhancing banana bunch yield through feeding N and K through distal end of rachis: For detailed procedure click this Link.
There is considerable increase in bunch size in ‘Robusta’ and ‘Grande naine’ banana, when feeding the following mixture through the distal end of rachis soon after fruit set.  
Preparing the nutrient mixture:
  • Ammonium Sulphate            -           15gm
  • Sulphate of potash (SOP)    -           7.5gm
  •  Fresh cow dung                    -           500gm blended in 100 ml of water.
(Cow urine can also be used instead of water. 500 gm of fresh cow dung contains substantial amounts of about 5.5gm of N, 3.5gm of K 1.6 gm of S besides other minerals and bio-chemicals).
Method of application:
v     Select bunches where the fruit set is complete and about 10 – 15 cm long rachis is available after the last hand. Avoid bunches where fruit set is incomplete or during partial deflowering time.
v     Remove male flower bud close to the rachis.
v     Take the already prepared nutrient slurry in a used milk bag.
v     Insert the slurry filled bag into the de-navelled stalk end of the bunch and tie it with a strong string.



Benefits:
Ø      Bunch weight increased by 67% over control in which male flower bud was retained till harvest. In the field demonstrations, a response of 22 % to 28% increase in bunch weight was evident. Using ‘N-isotope label the movement of 51% of N into the bunch from AmSo4 was confirmed.



(Courtasy: ICAR News, Research update, Success story, April – June 2007).
For EXPORT of banana fruits, buyers normally insist on the following practices also in addition to the ones described above:

8.  Size of fruit preferred for export:

41mm fruit measuring tool kit
  •  Exporters won’t prefer fully developed bunches that are ready for harvest. A bunch with a middle fruit in It’s 2nd hand measuring 41 mm dia, and the middle fruit in the last Hand with 35 mm dia two weeks before harvest is ideal for Export.
 
  • Normally there will be variation in the size of fruits located in the upper hands and lower hands. Fruits in the upper hands are always bigger than fruits in lower end hands.  The variation will be more and markedly visible if there are more than 10 hands (sometimes 13 to 15 hands) in the bunch. To procure more or less uniform size of fruits, exporters insist the farmers to maintain only 9 or 10 hands in the bunch. By restricting the number of hands to 9 to 10, availability of nutrients to the fruits are more resulting in uniform size of fruits and faster development. 
41mm is preferred fruit size for export














    9.  The practice of ‘Finger thinning’ is also to get uniform size of fruits.

















    10.  Retaining a finger in the last hand
    After de-navelling (removal of male floral bud), the distal end of rachis sometimes gets infected with fungus and if left uncured the fungal infection spreads to the upper hands causing extensive damage. Retaining a finger in the last hand is a practice to monitor the fungal infection since the symptoms can be easily spotted in a lone fruit rather than spotting it in the major part of the bunch.
    Leaving a single finger in the last hand











    Excellent yields are obtained in many fields of farmers at Theni District, Tamilnadu, where the farmers followed only few of the bunch care techniques described here above. But, they meticulously followed the 'Bunch sprays' described in Sl.No.6, Option 3, Important Notes 1 & 2  and covered the bunches with bunch covers / sleeves. To attain max. yield in banana, the crop has to be nourished properly from day one. One of the main reason for the farmers achievement other than bunch care and bunch sprays is their adherence to the "Fertilizer Target Chart" (Link: Fertilizer Target Chart for better nutrition management in banana - Kindly refer the comments section also for better understanding) given to them for giving timely, adequate and balanced nutrition to the crop.



         
    Regards,
    A.Vishnu Sankar.

    10 comments:

    Unknown said...

    sir very informative. thank you

    SIJI GEORGE said...

    Sir,
    Very informative for new comers like me. I have a small farm of G9 banana here in mysore and it started bunching. I have many plants having 14-15 hands do I need to remove some of the hands?.Is there any negatives for banana bunch feeding? Whether I can use nitrate Nitrogen like KNO3 or Ca(NO3)2 instead of ammoniacal nitrogen such as amm.sulphate and urea for bunch feeding.

    Tissue Culture Banana Cultivation Technology said...

    Dear Friend,

    Do not go for thinning of fingers without knowing where you are going to market your produce. If the size of fruit matters most go for thinning. If the number and weight decides price do not attempt thinning.
    There is no negative impact in banana bunch feeding. Initially practice bunch sprays and after knowing fully about the various fertilizers and their rate of impact evolve to direct bunch feeding.

    Unknown said...

    Please sir regarding the bunch feeding technique, when the milk bag is tied with a string to the denavelled end of the rachis, should the denavelled end be in contact with the cowdung slurry fertilizer?

    Tissue Culture Banana Cultivation Technology said...

    Dear friend,

    Absorbing the nutrients in to the plant through cut end of rachis is the technique explained here. So the cut end must be immersed in the nutrient solution.

    serious sam said...

    Thanks for providing good knowledge....
    Can you please provide some information that how can we protect/save banana from frost (0°c)
    I heard that applying folier spray of potassium nitrate can prevent damage from frost
    Regards

    Deva said...

    Dear sir,
    I have planted kathali banana in erode dt , and about 150 days old.Drip fertigation followed as per general recommendation, Last 3 or 4 banana leaves are fully white and tissue paper like and get sticky and got entangled and not opening. as per Agri , this is due to high ambient condition and recommended all-19, micro nutrients spray as well as thro drip. please advice the correct treatment . Day temp goes as high as 42 deg.
    regards

    dev

    chege said...

    Very informative article for farmers interested in banana farming, am gonna utilize this information in ma small farm. Thanks for sharing

    Unknown said...

    Very informative article for farmers interested in banana farming, am gonna utilize this information in ma small farm. Thanks for sharing

    Unknown said...

    Dear Sir:
    Thank you for so much valuable information. I write to you from Ecuador, the # 1 banana exporter in the world. I am very excited about trying your solution to improve bunch weight thru a bag tied to the rachis with K Sulphate and cow dung. Do we need to leave the bag tied up until harvest of the bunch? Or should we take it out at some predeterminate time? In my country the bunch takes from 11 to 13 weeks maximum to achieve optimal size and weight. And this year bunch weight has been very poor versus other years. Most agronomists are attributing this to global warming and excessive UV radiation stress on the plant. Others think that most fertilisers imported from China these days, may have dangerously high levels of heavy metals. Anyway, I will run the test and will post results on my grand naine banana plants.
    Regards,
    Xavier Alarcon
    Guayaquil - Ecuador

    Total Pageviews

    Twitter Delicious Facebook Digg Stumbleupon Favorites More

     
    Design by Free WordPress Themes | Bloggerized by Lasantha - Premium Blogger Themes | fantastic sams coupons